Denis Joseph Nexum Hardware.

Ibm Travelstar

Laptop Data Recovery

The worst thing that can happen to most laptop users, aside from the loss of the whole laptop, is hard drive failure. The hard drive holds all of your data, files, and all your e-mails and contacts if you use Outlook, Eudora, or any other non-portal based e-mail. But I'm sure many more laptops have gone to the recycling facility with live hard drives than dead hard drives. If you have any files you value on your hard drive that aren't backed up, you should invest $10 or $15 in a USB shell and attempt to recover the data. Hard drive data recovery is thought to be an arcane art, requiring expensive equipment and a high level of technical skill, but all of that only comes into play if the onboard electronics or the motor have failed. In that case, the drive platters are removed from the metal case in a special clean room, and the data is recovered by reading it off on a universal reader.
Most laptop owners are still very foggy as to where their data resides and consider the whole lower part of the laptop (everything except the screen) to be part and parcel with the hard drive. In reality, laptop hard drive are 2.5" wide, about 4" long and about a quarter inch thick. They weigh a couple of ounces, and can normally be accessed by removing a single screw from the laptop, as shown above.You should always unplug the laptop and remove the battery such as IBM 92P1101 Battery, IBM 92P1087 Battery and IBM 92P1102 Battery before attempting to do any repair work. I'll admit I left the battery in here, because I knew it had been stone dead for some six months or more, since the AC adapter died. After removing the single screw, you can see the 2.5" laptop hard drive installed in its cage. This hard drive is an IBM Travelstar, perhaps the most common hard drive used in laptops the past couple years. Because it's an older laptop, there's no shock mounting for the drive, little rubber washers that have become a popular way to partially shield the hard drive from the vibrations that can cause head crashes, in which case you can't recovery the data with a million dollar lab.
The series of pictures at the top of this page are for the older parallel ATA (PATA) drives, the newer SATA laptop hard drive is shown at the bottom of the page. The next step is to remove the whole cage from the laptop, which involves pulling back on the cage to free the drive's IDE interface from the laptop connector. You can see to the right that the drive cage is held from lifting by two metal tabs, and that the screw that held the plastic lid on the drive bay went all the way through and secured the cage in the laptop. That's all that held it together, one screw, and it's a typical arrangement. It turns out that removing the old hard drive from the cage, once it's out, is generally a bigger job than removing the cage from the laptop, because there are four screws involved and they are often overtightened and strip when you try to remove them. But it's not necessary to take it apart any further if all you want to to recover your old files.
To the left, I'm holding the new USB 2.0 interface that came with the $14.95 Sabrent hard drive enclosure I bought from itsbattery.com for $14.95. The interface is really all you need to gain access to the old hard drive, if it's healthy, and recover your data. The kit comes with software from Mac users as well as Windows based machines, but modern operating system versions don't even require the software. They'll just find the new USB hardware when it's plugged in, recognize that it's a hard drive, and allow you to recover your files as long as the file system types were compatible. I'm holding the interface card over the aluminum enclosure in which you could install the drive if you wanted to use it as a permanent external hard drive.
But when I started taking the screws out of the cage, three out of four fought me and the fourth stripped, despite the fact I was using a high quality screw driver. It would be easy to bend and break the remaining tab off to remove the cage, but why bother, when the only point of the job is to recover some old files? So I plugged the interface on (to the right), then set the whole thing down on my table with the new laptop and plugged it into the USB 2.0 port. You can see that the little green LED on the drive is lit and active, if you have good eyes and a better imagination.
Immediately after plugging in the USB cable, Windows XP picked up on the drive, and asks what you want to do with it. Choose "View with Explorer" and you'll gain access to all of the old folders, drag them onto your new laptop hard drive, and your data recover job is complete. Well, after you burn the recovered files on a DVD it will be complete, and you won't face the worry again. If the LED doesn't light up, you could be plugging the USB into an old port that doesn't source the 500 mA required, or the interface could be bad out of the box, or the drive could really be dead. If you don't hear the drive spin up, you can try picking it up gently, a few inches over the table, and try rocking in slowly to see if you can feel the centripetal force of the disk spinning.
In the 2005/2006 time frame, laptops started changing over from the older IDE (PATA) hard drives to the newer SATA hard drive. The only difference, as far as the user is concerned, is that the SATA drives are faster and have a different connector. The drives are otherwise identical, and the SATA drives often cost less in the larger capacities as they are more common today. Since the SATA interface only requires a few wires (serial vs. parallel bus), ribbon cables aren't required and a more flexible and robust connection is possible. The picture to the right shows an SATA drive installed in the laptop bay, and thanks to the rubberized shock mounting around the bay and on the cover, it simply sits tightly in place - no screws required. I only needed to remove one screw to take this drive out and put it into an SATA USB enclosure, and that was the screw on the drive bay lid.
Mounting the SATA drive on the circuit card for the external USB enclosure involves sliding the SATA edge connector into the circuit board connector and putting in a couple screws to hold it, if you're going to make the enclosure its permanent home. But don't make the mistake of thinking you're going to be able to boot your laptop from an external SATA hard drive, I haven't come across the laptop BIOS that can handle it yet. When the laptop BIOS gives you a "USB boot" option, it's the option to boot from a memory stick. Sabrent makes an SATA hard drive shell which costs $22.95 from itsbattery.com. In any case, if your laptop is a brick and you need to recover your data, pulling out the hard drive and putting it in an external USB case is usually the easiest approach, providing that the hard drive itself isn't fried.

About the Author

20GB IDE IBM Travelstar 9.5mm 4200RPM ATA-5 IC25N020ATMR040 $18.92 20GB IDE IBM Travelstar 9.5mm 4200RPM ATA-5 IC25N020ATMR040

20GB IBM Travelstar 20GN 9.5mm 4200RPM ATA-5 66Mbps DJSA-220 $21.04 20GB IBM Travelstar 20GN 9.5mm 4200RPM ATA-5 66Mbps DJSA-220

12GB IBM Travelstar 20GN 9.5" ATA-66 4200RPM 512KB 05K9229 $45.99 12GB IBM Travelstar 20GN 9.5" ATA-66 4200RPM 512KB 05K9229

30GB IDE IBM Travelstar 80GN 4200RPM 2MB ATA-5 9.5mm IC25N030ATMR04 $26.99 30GB IDE IBM Travelstar 80GN 4200RPM 2MB ATA-5 9.5mm IC25N030ATMR04

40GB IBM Travelstar 40GNX 9.5mm 5400RPM ATA-5 IC25N040ATCX05 $36.77 40GB IBM Travelstar 40GNX 9.5mm 5400RPM ATA-5 IC25N040ATCX05

20GB IBM Travelstar 30GN 9.5mm 4200RPM ATA-5 IC25N020ATDA04-0 $20.91 20GB IBM Travelstar 30GN 9.5mm 4200RPM ATA-5 IC25N020ATDA04-0

40GB IDE IBM Travelstar 40GNX 5400RPM 8MB 9.5mm IC25N040ATCS05-0 08K1092 $38.92 40GB IDE IBM Travelstar 40GNX 5400RPM 8MB 9.5mm IC25N040ATCS05-0 08K1092

40GB IDE IBM Travelstar 80GN 4200RPM 9.5mm IC25N040ATMR04 $36.92 40GB IDE IBM Travelstar 80GN 4200RPM 9.5mm IC25N040ATMR04

30GB IDE Hitachi IBM Travelstar 80GN 4200RPM 2MB ATA-5 9.5mm IC25N030ATMR04-0 $26.99 30GB IDE Hitachi IBM Travelstar 80GN 4200RPM 2MB ATA-5 9.5mm IC25N030ATMR04-0

Hitachi Travelstar 320GB Hard Drive $62.5 Hitachi Travelstar 320GB Hard Drive

Hitachi Travelstar 500GB Hard Drive $82.5 Hitachi Travelstar 500GB Hard Drive

Hitachi Travelstar 500GB Hard Drive HDT545050A38DA $62.5 Hitachi Travelstar 500GB Hard Drive HDT545050A38DA

Hitachi / 60PK 160GB TRAVELSTAR Z5K320 / 0A78601-60PK $3540.9 Hitachi - 60PK 160GB TRAVELSTAR Z5K320 - 0A78601-60PK

Hitachi / 250GB TRAVELSTAR Z7K320 SATA / 0J13212 $93.45 Hitachi - 250GB TRAVELSTAR Z7K320 SATA - 0J13212

Hitachi / 60PK 320GB TRAVELSTAR SATA 7200 / 0A78743-60PK $3873.99 Hitachi - 60PK 320GB TRAVELSTAR SATA 7200 - 0A78743-60PK

Hitachi / 50PK 750GB TRAVELSTAR 5K750 / 0J11563-50PK $4996.62 Hitachi - 50PK 750GB TRAVELSTAR 5K750 - 0J11563-50PK

Hitachi / 60PK 320GB TRAVELSTAR Z5K500 / 0J11283-60PK $3551.4 Hitachi - 60PK 320GB TRAVELSTAR Z5K500 - 0J11283-60PK

Hitachi / 60PK 500GB TRAVELSTAR Z5K500 / 0J11285-60PK $4766.12 Hitachi - 60PK 500GB TRAVELSTAR Z5K500 - 0J11285-60PK

Hitachi / 160GB TRAVELSTAR Z5K320 SATA / 0A78601 $80.97 Hitachi - 160GB TRAVELSTAR Z5K320 SATA - 0A78601

Hitachi / 60PK 320GB TRAVELSTAR Z5K320 / 0A78603-60PK $3523.1 Hitachi - 60PK 320GB TRAVELSTAR Z5K320 - 0A78603-60PK

Hitachi / 50PK 500GB TRAVELSTAR 5K500.B / 0A57915-50PK $4128.46 Hitachi - 50PK 500GB TRAVELSTAR 5K500.B - 0A57915-50PK

Hitachi / 320GB TRAVELSTAR Z7K320 SATA / 0J13213 $93.45 Hitachi - 320GB TRAVELSTAR Z7K320 SATA - 0J13213

80GB SATA-150 Hitachi Travelstar 5K100 0A27464 $50.25 80GB SATA-150 Hitachi Travelstar 5K100 0A27464

80GB SATA Hitachi Travelstar 5K100 0A27474 $53.56 80GB SATA Hitachi Travelstar 5K100 0A27474

80GB SATA-150 Hitachi Travelstar 5K100 5400RPM 0A26924 $51 80GB SATA-150 Hitachi Travelstar 5K100 5400RPM 0A26924

Hitachi Travelstar 4K40 40 GB Internal Hard Drive HTS424040M9AT00 $74.52 Hitachi Travelstar 4K40 40 GB Internal Hard Drive HTS424040M9AT00

Hitachi Travelstar Z7K320 HTS723232A7A364 320 GB Internal Hard Drive 0A78743 $80.95 Hitachi Travelstar Z7K320 HTS723232A7A364 320 GB Internal Hard Drive 0A78743

40GB IDE Hitachi 9.5mm Travelstar C4K40 1.8" 4200RPM HTC424040F9AT00 $114.19 40GB IDE Hitachi 9.5mm Travelstar C4K40 1.8" 4200RPM HTC424040F9AT00

20GB IDE Hitachi Travelstar 40GN 4200RPM ATA-100 9.5mm 07N9267 $24.14 20GB IDE Hitachi Travelstar 40GN 4200RPM ATA-100 9.5mm 07N9267

40GB IDE Hitachi Travelstar 5K100 5400RPM 8MB 9.5mm HTS541040G9AT00 $28.88 40GB IDE Hitachi Travelstar 5K100 5400RPM 8MB 9.5mm HTS541040G9AT00

80GB SATA Hitachi 5K100 Travelstar 2.5" 0A27484 $55.78 80GB SATA Hitachi 5K100 Travelstar 2.5" 0A27484

30GB IDE Hitachi Travelstar 4K40 4200RPM ATA-5 9.5mm HTS424030M9AT00 $28.99 30GB IDE Hitachi Travelstar 4K40 4200RPM ATA-5 9.5mm HTS424030M9AT00

100GB IDE Hitachi Travelstar 7K100 7200RPM 8MB 9.5mm HTS721010G9AT00 $114.52 100GB IDE Hitachi Travelstar 7K100 7200RPM 8MB 9.5mm HTS721010G9AT00

30GB Hitachi Travelstar 4K40 9.5mm 4200RPM ATA-5 HTS424030M9AT00 $28.99 30GB Hitachi Travelstar 4K40 9.5mm 4200RPM ATA-5 HTS424030M9AT00

40GB SATA Hitachi Travelstar 5K160 5400RPM 8MB 9.5mm HTS541640J9SA00 $13.49 40GB SATA Hitachi Travelstar 5K160 5400RPM 8MB 9.5mm HTS541640J9SA00

80GB IDE Travelstar 4K120 4200RPM 8MB ATA-6 9.5mm 0A26307 $49.88 80GB IDE Travelstar 4K120 4200RPM 8MB ATA-6 9.5mm 0A26307

60GB SATA HP/ Hitachi Travelstar 5K100 5400RPM 9.5mm 2.5in HTS541060G9SA00 $53.71 60GB SATA HP/ Hitachi Travelstar 5K100 5400RPM 9.5mm 2.5in HTS541060G9SA00

80GB SATA Hitachi Travelstar 5K100 2.5" 0A27404 $52.15 80GB SATA Hitachi Travelstar 5K100 2.5" 0A27404

80GB SATA Hitachi Travelstar 5K160 5400RPM 8MB 9.5mm Oem HTS541680J9SA00 $30.93 80GB SATA Hitachi Travelstar 5K160 5400RPM 8MB 9.5mm Oem HTS541680J9SA00